《宝钢色卡号码与日本、RAL色卡号码对照表》.doc

宝钢分公司设计200627号关于使用宝钢色卡号码与日本、RAL色卡号码对照表的通知各有关单位： 设备及管道的涂漆颜色在宝钢建设工程工厂设计统一技术规定中有明确的要求，为使宝钢色卡在对应日本色卡、RAL色卡时有一个统一的标准，现将宝钢色卡号码与日本、RAL色卡号码对照表（见附件）发给你们，请参照执行。附：宝钢色卡号码与日本、RAL色卡号码对照表 二OO六年七月十八日送：宝钢分公司设计管理部 2006年7月19日印发（共印发20份）宝钢色卡号码与日本、RAL色卡号码对照表 COMPARISON OF BAO STEEL COLOR CODE AND JAPAN,RAL COLOR CODE 宝钢股份公司宝钢分公司设计管理部二OO六年七月宝钢色卡号码和日本、RAL色卡号码对照表 COMPARISON OF BAO STEEL COLOR CODE AND JAPAN,RAL COLOR CODE序号No.设备名称Designation涂漆色彩Painting Color宝钢色卡号码Bao steel color code颜色Color日本色卡号码Japan 2001 color codeRAL色卡号码RAL1一般机械General machinery507灰绿 Grey greenA37-60DRAL 60212电动机Motor3室内吊车IndoorCrane本体Body102奶油黄Cream yellowA22-80LRAL 1014控制室内部Within control room503豆绿 Pea greenA39-80HRAL6019扶手 Hand railing108金黄Golden yellowA19-75XRAL 10034室外吊车Outdoor crane507灰绿Grey greenA37-60DRAL 60215码头吊车Deck crane6移动机械Movable machinery7堆料机Stocker取料机Extractor堆焦车，装煤车，其他Coke stacking carriage, coal loading carriage and miscellaneous8烟筒（包括排烟管）Stack(including exhaust fume duct)804银粉色SilverAN-75RAL90069安装在设备上的扶手Hand railing mounted on machine108金黄Golden yellowA19-75XRAL 100310除尘设备Dust extractor702中灰棕Middle gray brownA17-50DRAL 802511有耐热要求的设备，如炉壳等Equipment with heat resistant requirement such as furnace shell etc.804银粉色SilverAN-75RAL900612有耐酸耐碱要求的设备Equipment with acid and alkaliresistant requirement 509木犀绿Osmanthus greenA35-50HRAL601113有耐油要求的设备Equipment with oil resistant requirement504中绿Medial greenA39-60DRAL602114地坪格栅，盖板，踢脚板Grillage, cover plate and skirtboard on the ground605尘灰Dust grayAN-55RAL702315平台格栅，盖板，踢脚板Grillage, cover and skirtboard on the platform509木犀绿Osmanthus greenA35-50HRAL601116厂内管架，管桥Pipe support, pipe bridge inside the plant702中灰棕Middle gray brownA17-50DRAL 802517厂外管架，管桥Pipe support, pipe bridge outside the plant702中灰棕Middle gray brownA17-50DRAL 802518扶手，包括梯子扶手Handrailing including ladder railing108金黄Golden yellowA19-75XRAL 100319联轴器安全罩Coupler, safety hood303火红Fire redA05-40XRAL300020转轴包括联轴器Revolving shaft including coupler303火红Fire redA05-40XRAL300021管道支架，运输机机架，其他屋外构筑物Piping support, transportor stand and other outdoor structures702中灰棕Middle gray brownA17-50DRAL 802522气柜Gas holder本体Body602铂灰Platium grayAN-75RAL 7038走台，踏梯Walkway, stair702中灰棕Middle gray brownA17-50DRAL 8025扶手Hand railing102奶油黄Cream yellowA22-80LRAL 101423油槽Oil tank602铂灰Platium grayAN-75RAL 703824氧气罐O2 Tank804银粉色SilverAN-75RAL900625氮气罐N2 Tank26水槽Water tank27锅炉Boiler28高炉等的高热设备High temperature equipment such as blast furnace etc.507灰绿Gray greenA37-60DRAL 602129喷煤粉专业设备Special coal powder injection equip.604银灰Silver grayA57-60CRAL704630钢卷鞍座，钢卷存放装置Coil storage, Coil storing unit504中绿Medial greenA39-60DRAL 602131吊具存放架Storing stand for hoisting set504中绿Medial greenA39-60DRAL 602132卷取机侧栅门Side grating gate for coiler509108/802木犀绿Osmanthus green金黄/黑色Golden yellow/Black A35-50HA19-75X / AN-10RAL 6011RAL1003/RAL 900533开卷机，卷取机处滑动盖板Sliding cover at uncoiler and coiler108/802金黄/黑色Golden yellow/BlackA19-75X / AN-10RAL1003/RAL 900534预埋件Preembedded elements605尘灰Dust grayAN-55RAL 702335轧机，平整机顶部平台的护板梯子的扶板Hand board for ladder with guard damper at top platform for the rolling mill and temper101/504浅象牙黄/中绿Light ivory yellow/Medial greenA22-80D/A39-60DRAL1015/RAL602136通风管道Ventilation piping80437球罐（包括梯子，平台，扶手）Ball tank (including ladder, platform and hand railing)804银粉色SilverAN-75RAL 900638炉子Furnace80439冷却水循环罐Cooling water Circulation tank80440钢结构平台Structure deck507灰绿Gray greenA37-60DRAL 6021电气设备Electrical equipment1电动机和附件Motor and accessories507灰绿Gray greenA37-60DRAL 60212变压器Transformer602铂灰Platium grayAN-75RAL 70383屋外电气设备Outdoor equipment602铂灰Platium grayAN-75RAL 70384柜、盘、箱和台等Cubic, Panel, box and desk, etc.电气室，操作室等内部Inside E/R, pulpit, etc.现场盘Local Panel612510硅石灰Silicon gray祖母绿Grand m greenA25-70BA42-40HRAL7032RAL60015普通电线、电缆管道，桥架General wire conduit, cable duct, rack602铂灰Platium grayAN-75RAL 70386一般按钮General Push button 运转 Run 停止Stop 紧急情况Emergency514302302绿 green朱红Bright red朱红Bright redA42-30HA05-40VA05-40VRAL6020RAL 3001RAL 30017指示灯或带灯按钮Indication lamp or Push button with lamp 运转Run 停止Stop 断路器/开关闭合MCB/switch ON 断路器/开关断开MCB/switch OFF 电源闭合Power ON 重故障Heavy fault 轻故障Light fault514302302514801302108绿Green朱红Bright red朱红Bright red绿Green白色White朱红Bright red金黄YellowA42-30HA05-40VA05-40VA42-30HA19-92BA05-40VA19-75XRAL 6020RAL 3001RAL 3001RAL 6020RAL 9001RAL 3001RAL 10038一般电缆管、配线槽，电缆桥架General wire conduit wiring channel.Wire tray602铂灰Platium grayAN-75RAL 7038管道颜色Piping Color1高炉煤气BFG602铂灰Platium grayAN-75RAL 70382焦炉煤气COG602铂灰Platium grayAN-75RAL 70383混合煤气Mixed Gas602铂灰Platium grayAN-75RAL 70384转炉煤气LDG602铂灰Platium grayAN-75RAL 70385空气Air602铂灰Platium grayAN-75RAL 70386蒸汽Steam804银粉色SilverAN-75RAL90067氧气Oxygen405浅兰Light blueA69-60LRAL50248氮气Nitrogen108金黄Golden yellowA19-75XRAL10039氩气Argon606中灰Middle grayAN-50RAL700010氢气Hydrogen804银粉色SilverAN-75RAL 900611保护气体Protective gas602铂灰Platium grayAN-75RAL 703812生活水Domestic water511草绿Grass greenA37-50LRAL 601013工业水Industrial water511草绿Grass greenA37-50LRAL 601014过滤水Filtered water511草绿Grass greenA37-50LRAL 601015纯水Pure water406烛光兰Candle blueA69-50TRAL 501216重油Heavy oil704深赭石棕Dark ochre brownA17-50LRAL800117液压站用油Oil for hydraulic station102奶油黄Cream yellowA22-80LRAL 101418消防管道Piping for fire fighting302朱红Bright redA05-40VRAL 300119除尘管道Piping for dust removal602铂灰Platium grayAN-75RAL 703820循环水Circulation water514绿色GreenA42-30HRAL 602021生产下水Drainage for production511草绿Grass greenA37-50LRAL 601022雨排水Rain draining water404天蓝Sky blueA65-80H23冷凝水Condenser water511草绿Grass greenA37-50LRAL 601024废酸Waste acid511草绿Grass greenA37-50LRAL 601025新酸New acid511草绿Grass greenA37-50LRAL 601026再生酸Regeneration acid511草绿Grass greenA37-50LRAL 601027漂洗水Rinse water511草绿Grass greenA37-50LRAL 601028含油废水Oil contained waste water511草绿Grass greenA37-50LRAL 601029硫氢化钠Sulfur sodium hydride30酸性废水Acid waste water511草绿Grass greenA37-50LRAL 601031含铬废水Chrome contained waste water511草绿Grass greenA37-50LRAL 601032碱性废水Alkaline waste water511草绿Grass greenA37-50LRAL 601033润滑脂Grease110铁黄Iron yellowA17-60HRAL 101134润滑油Lubricant oil104米黄Rice yellowA22-70HRAL 100135防锈漆Rustproof paint104米黄Rice yellowA22-70HRAL 100136灭火剂Extinguishing agent303火红Fire redA05-40XRAL 300037低温水 temperature water511草绿Grass greenA37-50LRAL 601038管道支架Pipe support702中灰棕Middle gray brownA17-50DRAL802539油气，油雾管道Piping for oil air and oil mist104米黄Rice yellowA22-70HRAL 100140乳化液，湿平整液Emulsion wet tempering solution102奶黄Cream yellowA22-80LRAL 101441标记牌Mark board601浅灰Light grayA29-80BRAL 9002管道（色带及箭头颜色）Piping (Band & Arrow Color)1高炉煤气BFG302朱红Bright redA05-40VRAL 30012焦炉煤气COG108金黄Golden yellowA19-75XRAL10033混合煤气Mixed Gas108302金黄Golden yellow朱红Bright redA19-75XA05-40VRAL1003RAL 30014转炉煤气LDG306大红ScarletRAL 30025空气Air6蒸汽Steam7氧气Oxygen412紫兰Purple blueRAL 50008氮气Nitrogen512铜锈绿Verdigris9氩气Argon10氢气Hydrogen306大红ScarletRAL 300211保护气体Protective gas110铁黄Iron yellowA17-60HRAL 101112生活水Domestic water412紫兰Purple blueRAL 500013工业水Industrial water803紫色PurpleA87-60HRAL 400114过滤水Filtered water103米黄Cream yellowA22-80HRAL 100115纯水Pure water803紫色PurpleA87-60HRAL 400116重油Heavy oil109铬黄Chrome yellowA17-70XRAL 100717液压站用油Oil for hydraulic station106镉黄Cadmium yellowA22-80VRAL 102318消防管道Piping for fire fighting801白色WhiteA19-92BRAL 900119除尘管道Piping for dust removal802黑色BlackAN-10RAL 900520循环水Circulation water601浅灰Light grayA29-80BRAL 900221生产下水Drainage for production601浅灰Light grayA29-80BRAL 900222雨排水Rai